HarleyTechTalk

Technical Forums => Shovel Head => Topic started by: Chippitt68 on June 11, 2022, 07:11:04 PM

Title: 1982 flh starter issues
Post by: Chippitt68 on June 11, 2022, 07:11:04 PM
I was trying to start the bike today and the starter turned the motor over a few revolutions. The starter disengaged and there was whirring sound coming from the starter. I could not shut it off with the ignition. I had to disconnect the neg battery cable to get it to stop. It ran for a couple minutes as I took seat off and got a wrench. The bike has the start button on the handlebars and one behind the oil tank. When I bought it the guy said he installed because he didn't trust the wiring in the handle bar controls. There is a delay on the right side that is mounted to the fender by the swing arm. I'll replace that tomorrow and see if that solves. Just wondering if anyone else has experienced anything like this?
Title: Re: 1982 flh starter issues
Post by: kd on June 11, 2022, 07:42:22 PM
Here's a thread from 3 days ago in General.

https://harleytechtalk.com/htt/index.php/topic,118024.0.html
Title: Re: 1982 flh starter issues
Post by: JW113 on June 11, 2022, 09:02:40 PM
Was it working fine until now? Or did you or someone "work" on it? It is imperative that the heavy cables on the solenoid under the battery tray, and the one on the primary, have the cables on the correct terminal posts. Else they will self-energize.

-JW
Title: Re: 1982 flh starter issues
Post by: Chippitt68 on June 12, 2022, 04:56:40 AM
Quote from: JW113 on June 11, 2022, 09:02:40 PMWas it working fine until now? Or did you or someone "work" on it? It is imperative that the heavy cables on the solenoid under the battery tray, and the one on the primary, have the cables on the correct terminal posts. Else they will self-energize.


-JW
Nothing was touched. It was working fine before this happened
Title: Re: 1982 flh starter issues
Post by: Hossamania on June 12, 2022, 06:25:21 AM
Kd posted a link to a thread that is most likely your problem.
Title: Re: 1982 flh starter issues
Post by: Chippitt68 on June 12, 2022, 11:28:19 AM
Quote from: kd on June 11, 2022, 07:42:22 PMHere's a thread from 3 days ago in General.

https://harleytechtalk.com/htt/index.php/topic,118024.0.html
Thanks KD. I appreciate the reply.
Title: Re: 1982 flh starter issues
Post by: Chippitt68 on June 12, 2022, 12:51:11 PM
Quote from: kd on June 11, 2022, 07:42:22 PMHere's a thread from 3 days ago in General.

https://harleytechtalk.com/htt/index.php/topic,118024.0.html
This one doesn't appear to be serviceable. The cover will not come off due to two wires that run up through the top and are soldered to the posts.  It does appear to be trash.
Any recommendations for replacement?
Title: Re: 1982 flh starter issues
Post by: xlfan on June 12, 2022, 10:19:11 PM
It happens usually when not enough cold crank amps are presented to the solenoid for some reason.
Title: Re: 1982 flh starter issues
Post by: Chippitt68 on June 25, 2022, 03:34:41 PM
The battery tested 12.8 volts and 377 cca. Relay tested out ok. The solenoid was replaced. It was in bad shape. The solenoid I got required some modification to get the solenoid in straight. It turned out to be the auxiliary starter button that was added by previous owner. I removed the wire from the button from the solenoid. Solenoid works as it should now.
Title: Re: 1982 flh starter issues
Post by: kink04fxd on June 29, 2022, 06:52:49 PM
Pull the disc out and clean it up with some sand paper or a small file. The upper stud will come out after you remove the nut and then turn it 180*and clean it up. Same with the lower stud. You can flip the disc 180* if you remove the small clip behind the spring. Or, you can just buy a new one.
Title: Re: 1982 flh starter issues
Post by: david lee on June 30, 2022, 02:38:46 PM
Quote from: Chippitt68 on June 25, 2022, 03:34:41 PMThe battery tested 12.8 volts and 377 cca. Relay tested out ok. The solenoid was replaced. It was in bad shape. The solenoid I got required some modification to get the solenoid in straight. It turned out to be the auxiliary starter button that was added by previous owner. I removed the wire from the button from the solenoid. Solenoid works as it should now.
that was my first thought a dodgy add on
Title: Re: 1982 flh starter issues
Post by: Chippitt68 on July 01, 2022, 03:09:33 AM
Quote from: david lee on June 30, 2022, 02:38:46 PM
Quote from: Chippitt68 on June 25, 2022, 03:34:41 PMThe battery tested 12.8 volts and 377 cca. Relay tested out ok. The solenoid was replaced. It was in bad shape. The solenoid I got required some modification to get the solenoid in straight. It turned out to be the auxiliary starter button that was added by previous owner. I removed the wire from the button from the solenoid. Solenoid works as it should now.
that was my first thought a dodgy add on
This one has its share of dodgy add ons.